万博体育maxbextx苹果|注册|歡迎您

网站公告:

新闻中心

万博体育maxbextx苹果|注册|歡迎您

电话:0531-69951198

邮箱:jingtuolt@163.com

传真:0531-69951198

地址:济南市历城区西周南路9号

网址:

企业动态

当前位置:首页 - 新闻中心 - 企业动态 - 空气增压系统的使用技巧要

空气增压系统的使用技巧要注意什么?

发布时间:2022-04-06 19:22:13   发布人:
1、调节驱动压缩空气气源压力要求不大于0.8MPa(8kgf/cm?)。
1. The pressure of the compressed air source for regulating and driving shall not be greater than 0.8MPa (8kgf / cm?).
2、接通被增压空气管路,被增压空气进气压力范围为1.5bar-16bar,接通管路后,可观察被增压介质空气压力表的数值,保证驱动气路系统的清洁和正常工作条件。
2. Connect the pressurized air pipeline. The inlet pressure range of the pressurized air is 1.5bar-16bar. After connecting the pipeline, observe the value of the pressurized medium air pressure gauge to ensure the cleanliness and normal working conditions of the driving air circuit system.
3、当被增压空气压力达到所设定压力,即空气气瓶被充满时,两边压力达到平衡状态,增压泵停止工作,这时可关闭压缩驱动气源,关闭两边空气气瓶,此时,打开高压开关,进行增压系统管路泄气,以便高压气体排出。排完后,则立即关死高压卸荷球阀,可进行下一次充气。
万博体育maxbextx
3. When the pressurized air pressure reaches the set pressure, that is, when the air cylinder is filled, the pressure on both sides reaches the equilibrium state, and the booster pump stops working. At this time, close the compression drive air source and close the air cylinders on both sides. At this time, open the high-pressure switch to vent the pipeline of the pressurization system, so that the high-pressure gas can be discharged. After the discharge, immediately close the high-pressure unloading ball valve for the next inflation.
4、紧固好空气增压系统及各连接管接头,防止因振动撞击擦产生静电火花。使用抗静电软管。
4. Fasten the air pressurization system and all connecting pipe joints to prevent electrostatic sparks caused by vibration, impact and friction. Use antistatic hose.
5、保持良好的排气和通风、远离易燃易爆和热源。
5. Keep good exhaust and ventilation and keep away from inflammables, explosives and heat sources.
6、泵的排气中可能含有固体物,不要将排气口对着工作区或者人,以免造成人身伤害。
6. The exhaust of the pump may contain solids. Do not face the exhaust port to the working area or people to avoid personal injury.
7、当输送易燃和有毒的流体时,请将排口接到远离工作区的安全地方。
7. When transporting flammable and toxic fluids, please connect the discharge port to a safe place away from the work area.
8、流体的高压可能会导致严重的人身伤亡和财产损失,请不要在泵加压时,对泵及料管系统进行任何的维修工作,如要做维修时,先切断泵的进气,慢慢松开连接的各管道接头。
8. The high pressure of fluid may cause serious personal injury and property loss. Please do not carry out any maintenance work on the pump and material pipe system when the pump is pressurized. If maintenance is required, first cut off the air inlet of the pump and slowly loosen the connected pipe joints.
9、为了保证泵的寿命,建议驱动气压≤8bar此系列的驱动活塞直径为160mm。
9. In order to ensure the service life of the pump, it is recommended that the driving air pressure ≤ 8bar. The diameter of the driving piston of this series is 160mm.
、保证所有接触输送体的部件不会被输送的流体腐蚀损坏,并且要保证所有的操作人员熟悉操作使用和掌握泵的安全使用注意事项,必要的话,配给必需的防护用品。
Ensure that all parts contacting the conveyor will not be corroded and damaged by the transported fluid, and ensure that all operators are familiar with the operation and use and master the precautions for safe use of the pump, and provide necessary protective articles if necessary.
今日就是小编为大家带来的精彩内容,更多的精彩内容关注我们的网站:万博体育maxbextx
Today is the wonderful content that Xiaobian brings to you. More wonderful content focuses on our website: gas-liquid booster pump
新闻推荐:
气液增压系统的使用需要注意对应的问题 2022-06-17
万博体育maxbextx苹果产品特点多达九点 2022-06-10
有关增压泵设备的几个特点 2022-06-01
增压泵对驱动气洁净度的要求 2022-05-29
入口压力的大小对万博体育maxbextx产生影响 2022-05-25
万博体育maxbextx苹果实际应用的相关内容 2022-05-13
万博体育maxbextx苹果这么多人用是因为其性能高支... 2022-05-06
万博体育maxbextx的选择要多关注什么? 2022-04-27
万博体育maxbextx苹果压缩的气体问题如何解决? 2022-04-20
空气增压系统的使用技巧要注意什么? 2022-04-06

13188935873

qq